HomeMy WebLinkAbout40 52nd Way File 1301 L'ORIENT STREET j�
V I �, �G ST.PAUL,MINNESOTA 55117
(651)558-3300•(800)-229-6263 /��
AUTOMATIC SPRINKLER CO. FAX:(651)558-3310 ��
SHEET t OF z-Use separate sheet for each bui�ding inspection REPORT OF INSPECTION
MINNESOTA LICENSE NO.C00005 WISCONSIN LICENSE NO.265989
REPORT TO BUILDING OR LOCATION
STREET `> >- %:�� _=- � _ � INSPECTOR � '� `���` -
CITY & STATE ",''.�.- DATE
Owner's Section (To be answered by Owner or Occupant)
A. Explain any occupancy hazard changes since the previous inspection: � �
B. Describe fire protection modifications made since last inspection. �
C. Describe any fires since last inspection.
D. When was the system piping last checked for stoppage, corrosion or foreign material?
E. When was the dry-piping system last checked for proper pitch?
F. Are dry valves adequately protected from freezing�
Signature � Title Date � � � �
Inspector's Section (All responses reference current inspection) NA =NOT APPLICABLE
1. General
a. Is the building occupied?.� Yes '�___No
b. Are all systems in service?:�Yes -No `
c. Is there a minimum of 18 in. (457 mm) clearance between the top of the storage and the sprinkler deflectors?,�i,Yes ❑ No
d. Does all electrical heat tape appear to be satisfactory?C'Yes =�No C� NA
e. Does the hand hose o� the sprinkler system(s) appear to be satisfactoiy? � �Yes No. =E��NA
2. Control Valves (See Item 15.)
a. Are all sprinkler system control valves and all other valves in the appropriate open or closed position?�I Yes ❑No
b. Are al] control valves in the open position locked, sealed or equipped with a tamper switch?�Yes ❑No
3. Water Supplies (See Item 16.) �
a. Was a water flow test of main drain made at the sprinkler riser(s)?'�Yes _No
4. Tanks, Pumps, Fire Department Connections
a. Are fire pumps, gravity tanks, reservoirs and pressure tanks in good condition and properly maintained?� Yes �_No i�NA
b. Are fire department connections in satisfactory condition,couplings free, caps in place, and check valves tight?�J Yes ❑No ❑NA
Are they accessible and visible?�Yes � No ❑NA
5. Wet Systems
a. Are cold weather valves (O.S. & Y.) in the appropriate open or closed position?.Ev Yes -�No ❑NA
b. Have antifreeze system solutions been tested?��Yes ❑No _'�NA
c. Were the antifreeze test results satisfactory?- Yes �No :�NA
d. In areas protected by wet system(s), does the building appear to be properly heated in all areas, including blind attics and perimeter areas
where accessible?�Yes ❑No - NA Do all exterior openings appear to be protected against freezing?-f�Yes ❑No ❑NA
6. Dry System (See Items 11 to 13.)
a. Are dry valve(s) in service? _Yes __No �NA
b. Are the air pressures and primi�g water levels in accordance with the manufacturer's instructions?u Yes 'i� No ,�]NA
c. Has the operation of the air or nitrogen supplies been tested?❑Yes '= No � NA Are they in service?�Yes ❑No �NA
d. Were low points drained during this inspection?—Yes -No .❑NA
e. Did quick-opening devices operate satisfactorily?`Yes _No �Y NA
f. Did the dry valve(s) trip properly during the trip pressure test?❑ Yes ❑No .4�NA
g. Did the heating equipment in the dry-pipe value room(s) operate at time of inspection ?� Yes ❑No -Q NA
7. Special Systems (See Item 14.)
a. Did the deluge or pre-action valves operate properly during testing?❑Yes C No �NA
b. Did the heat-responsive devices operate properly during testing?-' Yes ❑No ��NA
c. Did supervisory devices operate during testing?�'Yes '-'No �NA
8. Alarms
a. Did water motor(s) and gong(s)tesC satisfactorily?❑Yes r No 0 NA
b. Did electric alarm(s) test satisfactory?C Yes r No -NA
c. Did supervisory alarm service test satisfactory?C Yes �No �NA
9. Sprinklers
a. Are all sprinklers free from corrosion, loading or obstruction to spray discharge ?�Yes No
b. Are sprinklers less than 50 years old?(Older sprinklers require sample testing)� Yes �� No
c. Are quick response and residential sprinklers less than 20 years old?(Older sprinklers require sample testing).�Yes ❑No
d Is stock of spare sprinklers available?O Yes ❑No
e. Does the exterior condition of sprinkler system appear to be satisfactory ?C'Yes _ No
f. Are sprinklers of proper temperature rating for their locations?r Yes �No
10.Explain any "No" answer and comments:
Signature: Date:
m • • 5. ... •.. �� .. � ,.... .v - . ._ . . �
1 . u �Y ��3 . . . . � ' . . .,
� AE �"� 'i^ K-,`�&"TT„' 3 . - . � '.
r
. .y .- _ . . � �
�1."Y` a�x' ti.�t':i �2 � . ... �.,. ;,,.�: . � .
,c:. rc*..,.. -`t$' * ' a ._..-' '� : ' ' '.� .� --, .. . . � ' � .. : " ... . , . I '' . .. '
.. . . _ . :'�ns"`S•`'�'�5`r+,�at�+„+r � . . - - . . . � - , , �
� .._ r,« _ . . . . �,
_ "�^K '� �, k _ . . �� .
. . '��;� � . � - � � � . ,. . .
. � ,��,Y. , �'. . . . . . �. � . . . , . ._ � . i . . .. ,, �
� _ �,
. . S.�_ ,af .. -. . . � � . . . � .
- _ x .���_ : , � � � .. � , � I � .. .
� � ' ��.- , ��.
;.
..,�. . �.� �i�"`= ' ' '. :. " .. � . � �. . � . ..
.V... . . .. . . . �� . . , �
:: _�r ,- � � .,,_•.. ,
'. � ,�.:? . " ' ' � ,..� � � � . .. ' . . � .
5-� - :T - 1 _ . . _. _. .. . i � � � . .
� _ , - . - - , . _ . . i .
... ..�. �. , , .
� . . . . . . . �. . I . .
.. . . . _ .I . ,. . .
..�i!" � - . . ��� . . . ' . . , . .
.. ��� . � . .. �1 . � ��.,
� � ' :� . . � . . .._ � . . � :��. . , .
�.-x ,. .. .. . � , . � .. _ ..
f ; � � � :S ! �' � . � . . . �- . . _ .. .
���� �� � � �
fi �,+ ay
� ���"�,� . � . . . � : _ � . . � . . ..
��� � � i
�' _ �
:t
, * F; ry
�,-' � ., i ,
�1 �' F��,¢ "' '� `T ."� : . � .. .. . i .. . � . . .
n � �
�y.��� � y p' .f`'M fZ
, ., � �rs,� � r� < . . .�.. I . _ . .
.
.. s�'i���`�F `�s�' .l�, P.; '`�4 ai,t,.` ;�:I . � � � .. �'. .
�5 t te .�
�N`�« � �v �>'�•rY£G�L;�" . P - � - i � . . .. �,.
r_
.
+��51''� -�"�' " 1 .. ' .. . . ' -' ... .. '�.
' ' ' _ , . . . I , .
. _ . ' � � . . I ��. ' � , ,. '�
, '_� . . - . . . ,- {� ' ��
y�,; '�' a r y . , . - . — . I _ . . ,
�� . . . . I . , .
. +R�' .3 Y+ . �� � � . � ... � .. . . � .
�.
, '"'. .J ._ . �.._'. ' ,. , : . . . . . -
. ' -: .e .,. _. .., . � .. . .
�
.. � . . .. . . . .. . . . .. . - - � .
�.
, .��" - .'. �•" � . . � ,
.. �.� ,.�. . . . ... .
' ..._ ��a ._<� . _ 4 ..—� ��....�..._..:.. _.. . � .
'�E81 1� a � 'a�' , . � . . � . .
,.
S� �.:p3r�'������N'�X �`�" Y` � - . . - . .. • � . . � . . .. .
.:
� ,� 3 s�` „ .': _ " "���- I _
;ir s�
��� _ • . � . . r . � � . . • ��.
?S �`�"y' Y'} ��T2 . . - . .. � � � . .. . � �.
�. �_ , . . .. . I. . ,
F . . -. . . . � I � . . � ' ',
. 2 � . . .. . . . . , . . . , .
C
f
., ... .._ � . +�� 3 � . . ,-. .. .. ,.,.. - _ ,.e.. . .,.. . t ,_.,�..�,._..
j 3 .5� � �'sa '�1�� M� i . � � . ' � . . . .
y 7;
' �,,� , L rxj� .. ' . . � ., I � � . � � - . , . . �
�
i 'c"'� �"',�w�,�'`,��, 1�yx'"�,�'� h c� � �'I �. .. . � ,. � �.� �,
k��? � f`Y fl_1 � i f� C . .. . _ �.
t,.� y�u�E�kd s ." '�. t � .. � .
>;
��Ka x � �+ ,� �� � �
1;.i,7 .�Y.�..G^.,y �a�' r � ?. . . .. ,�. , . '
#�"�*jp"S�" �i�y„}C t � . ' _ . � � .
:, � �..: -. � S I . . .
l<,. , y y . . _ . .
,� 1 �
�� x.�.r�'�"Hx",c�. � o i �_���'� �z� � , � , . .
� �1" � . . " � �, . .
'�v-a ri _y . . . . . .
.x=<: = y.� � '� :� -
�. .:_ *�� � �� � ; . . .. . .
, >
1 ' r t �
� � �.
. � `,'x;_ ' .. ' 3, r��i- . 1� � ,,..;.,.. , _,,,. .. :.
'�`��?�. -'�"'"",���i .�� ` �
4y,t
.�' 2 }n. K.'t� _'n��F+* � ' I. . . i � ' . 'i . . � .
kY�.�£�. ' � t 1 - . _ . I . � I
''�+ .X P � .�=kG � . � - , _ . � . � . � .
�• " i
1301 L'ORIENT STREET ,��~
V I �I N G ST.PAUL,MINNESOTA 55117
AUTOMATIC SPR1NIa.ER CO. FAX)(651)5�58 33100)-229-6263 ���
SHEET 2 rOF 2 - Use separaie sheet for each system inspection System No. or Description if multiple
. ._._ systems T;
Inspection Report � �� '�-�=�
�s: No.
11. Date dry-pipe valve trip tested �ontrol valve partially open) (See Trip Test Table which follows)
12. Date dry-pipe valve trip tested��(control valve fully open) (See Trip Tesf Table vyhich follows)
13. Date quick-opening device tested (See Trip Test Table which follows) �'
DRY VALVE TRIP TEST TABLE Q.O.D.
� MAKE MODEL SERIAL NO. MAKE MODEL SERIAL NO.
.. i
DRY PIPE � Time to Trip Water Air Trip Point Time Water Reache�f Alarm Operated
OPERATING Thru Test Pipe Pressure pressure Air Pressure Test Outlet F Properly
TeSr MIN. SEC. PSI PSI PSI MIN. SE . YES NO
W ithout
a.0.q'.
Witfi
Q.Q.D.
f
7
14. Date deluge or pr�action valve tested (See Trip Test Table which folloWs)
� -----TRIP TEST TABLE _
Operation ❑ PNEUMATIC `�❑ ELECTRIC ❑ HYDRAULIC �
�- Piping Supervised ❑ YES ❑ NO Detecting media supervised ❑ YES ❑ NO
DELUGE& Does valve operate from the manual trip and/or remote conhol stations ❑ YES ❑ NO
r'`'•<.: PREACTION Is there an accessible facility in each circuit for testing Method of testing-circuits
,,.:::,
1,-_� VAWES ❑ YES ❑ NO
Does each circuit operate Does each circuit �� Maximum time to
_!.� MAKE MODEL su ervision loss alarm o erate valve release o erate release
�; YES NO YES NO YES NO
:;�
`.�
<.i
� 15. See Control Valve Ma'intenance Table.
Control Valve Maintenance Table
Ezplain
Abnormal
Control Valves Number Type Open Secured Closed Signs Condition
City Connection Control
Valve
Tank Control Valves
Pump Control Valves
Sectional Control Valves
System Control Valves
Other Control Valves
Kitchen Control Valve
16. Water Flow Test at Sprinkler Riser
Water Supply Source: City Tank Pump
Date Test Pipe Size of Static Residual
Location Test Pipe Pressure (Flow)
Pressure
Last Water Flow Test
�
This Water Flow Test � ' '
17. Explain any "Nd' answers and comments:
18. Adjustments ar corrections made during this inspection:
;
�<
19. Although these comments are not the result of an engineering review, the following desirable improvements are recommended:
Signature: `��- = �-�`--� •- Date:
�
+
;
�
; . : _ :
�
�
, , , . , _ , _
�
�
__.��:.:.:_ ,
_ -- ---�----�_ ��
� ------ . �--= , :
_.._. _-- — ___—_, � . -
;, _
_ ,.
,., ,, �.
_. _ �„ �
;
, �
. ; � .,:
: — . . ,. :
,
. , M . . . „
,..... ,.., ,.. .. _ � .
� .,, ,
. _ , � � �
, _ . , �
, „ , . .
� ,s
, � -_ .. � , � :, ��
, � `
,< _ ,
�
, • . .
q.a
. . . , . '.,. ..� . . . . .. , .. . . . . � .. . . . . r�
,.. �.. .��.x ����:.y.: . ' ,�.. . ':''�a - ���- . �� -_�' . . � . [.. . ;.' " . .
�. �� . . �. : . ,' ., . . .. . . ... ..
' �'�"'., ,_. .:. . . .:�, .. ... ,w`-_'.. � ...�., .. `.. .
.
t:��- . ., . _._:... . ._ . . _ . ,�.�...., .. . . . � .,-,..C.. � ..�., .
�.i : . ... . :. . . . . . .. .. . . :,, �. � . . � . :
, . . � - . . . . . . . . . . ,
,,.� � ' ' .. . . . .. . ..
. �. .... , . ,,. .,. � .
:3 ,5` - 3'�� �� A .. .. ' _ . _ _ .._.
,. a
l � ��A�ji t, a 4 � "'� � ��` s Y n '.� fi :
��, �� K.t'�;:: � '.�,aC t,� � � � t 5 � ���'� e , t :�'�a��y v
� ta�: ,n- ��a ,�,�' 4 tv�.F,� �i`. L „�:: ��,� ��`� �_ .
� �. Hi y- - T,�y � � �* , :�
" q..:`�Jt � ;:�� zt �.� ,y � Y y ,��Y� ..�r�l' -+ y�•, � * �_ ��x t �
s r.�'�t� � 4`; ' T d �:� `' q �" '� v x, . � .
� �� *���+tr� yTx{ � �st�:d �� ���� �t ;. ° ky.. �- N° � �\ r s �� ..���� � X� ��.. r aM;h � �,
.«,�t `� e' 3 �* � � �.3 { �� �' �St�' u� 'r� �,.
4. ,r N- apF' 'g�.^�- '���u: +t �'a z.y��a .� t- � ,`�r �, �t�h�3 � �. �-'a`f :t �� '� � �� ��` `+ �
''�� r t ��; �:'� �� a y ' `'�^ "�'�+ x>. �''��t's.� t �.�;. i �x: � �;.
� �$1 , , s � _4n, s i .;t '�'�� +� "` '�4t �' � r
�'� �� �A��?r�". '� 'd� .�:�t c p,�?5P �� � 4-�. �. '��z 1,�a- t� �� J�"� ����� x 'R ��'t �
y� s .t i:�.� .� �-a ;�r t 9� ,�� ��i', F�, k . � ��*r�tq �; �� `r� �'v �n6. � �,r «r
:,`� ,� �.',' ra .._y sf`' ..� 'h'w .:�c.,�i au.`'i�n'f ��� �'�� '��it',.� �-�,��t�d���` � � -S k�y s'� 1 �t�,'� r�a. �* '�°,�� y�ti,.Y r�r
'��y ,, �Na3. S � r }t i�+�'" "`- � �: X � ` a �, �� � .�
"`� x � xh ���,`t�, �rt' 1.� u�F �� Y ^s; F �� a�� ��' � �.'�'� »� �i 4 �`� � �; �
} � ..r��.4 p '.�. � ��a.�Y� i_f'�" „3 �.a,. �,�,Y1��`'.'S�r ��.r. �,,,j^r �� �-r � '� ��� A:,.,, ''k, i"��.,� �' � iti ��.��� ' , i
�'. �'�'� � � � �
�y �'.b..'r�� � '�'� at•'+�;`� c.o-�" '�.�., S �7��' +'� �'��;- `�°�' � �'S � i1 � `� �" ,.J� J nsa �,p
�h� fi..,3'�4��� A �^ ���.� r� ir � ;Y x .t i` ��,-a } � �
��-k. �� aik, � k-�"�1 °'���� 3 tC �,, � �,a�aYC ��. T # t�� ^�� �Vr�� � g� ` � �.� '; �
� 'v-'�t >, t �s�tz� • �a�t � S' .- + � ''�� �'��a�a - �
E� ��� M �q,�a�,��7�� y �`"�, +�'�,a� a � ° +� , , � �a� � � ,��"9���y..3 {f
• n ;''�'' r ,� �^ �.h�' <�4 i " ��: vc >�'��, z,:w �
k'^ �'' � � 'r� � � h� v� - .1,
�
. .... �: . ,�. . . ,.._ .: ' . _
.. . ��_�: ,� ..
. �_. _ . _ � r ;. ,,- . , ' �-
„ ,
\ : , '
.. ., ... ., .. , .
,�.� , �. :. . �. <..�. . � . � .. �
.
_.c�. _ ?_,.�:._.. � '� . :� � � . .
...._ ,.. . . .. _..._. -. . .._. ...__. .. ... ... _. ,. » �
_,_ w
,: -� . .; ` ��. . � . -'. . ..._... ,-•°--,-- ... 4 - . ..
.. ... _� _ ., ... . ...__... .._.. .._. ....,._. .
,.: . ... r; . , :,.� �.,�; .. ,� �•:� ' . . � � . . . . ..��' , ��� � . ' �'��.
an
Construction, Inc.
6511 Cedar Avenue South • Minneapolis, Minnesota 55423 • (612) 866-4632 • Fax (612) 866-0390
August 27, 1998
City of Fridley
���A � �r�i�inr�i��i �fo�'+IIP ��
.. v i .J��ivl:�v���r ::v�:.,... :i
Fridley, MN 55432
Attn: John Hoskis-Engineering
Dick Larson-Fire Marshal
Re: Plunkett Pest Control
40 52�d Way
Fridley, MN
Gentlemen:
To follow up our phone conversations of Wednesday, August 26, R.J. Ryan will install a
solenoid that will shut off domestic water if the fire sprinkler system is activated.
Please do not hesitate to call with any questions.
Sincerely,
R.J. RYAN CONST N, INC.
Brian Trombley
BT:jk
Bt-plu-Iet10
An Equal Opportunity Employer
n.(P�roc��ctor's M.�tcri:�l :�ncl �r�si c��-ur�;��� r�►�� Al�uvc�roiin�l Pi��ing
((. ��i orms lo �f�t' 13- )94 N.Test llcscri��liou
Upon complellon of work, Inspecliun and Iesls shi�ll be made by Ihe Ilydruslnllc: Ilydruslalic Icsls shall be inadc al nol Icss thnn 2U0 psi (I).6
conl�nctor's�cpresenlulive nnd wilncsscd by an owncr's rcpresenlalive. All bars) for Iwo Iwu�s or 50 psi (l.4 bars)nbuve stnlic pressure in excess of
delecls sh:�ll be cu�tecled �nJ sysleiu Icll in service belbre cunliador's ISU psi(10.2 bnrs) for lwo hours. I)Illcraiti:il dry-pipe valve clap�x:rs shnll
personncl lin�illy Icnve Ihe job. A cc�lilicalc sh�ll bc lilled oul unJ si6ncd be Icli opcn during Iesl to picvenl damnge. All aboveground piping Icnkege
by boUi rcpresenlnlivcs. Cu�iics shi�ll bc prc�>:�rcd (ur approving aulhuri- shsill bc slopped.
lics,owne�s nnJ cunlrnclor. Il is �nnlcisluud Ihc o�w�c�'s rcpresenlalivc's 1'ncumnllc: 1?slnblish 40 psl (2.7 bars)nir pressurc nntl mcnsurc thop.
signalure in nu woy prejudices r�ny clnin�s�goinsl contr��dor for fuu11Y which shall nul exceed I.S�psi (0.1 bars) in 24 hr9. 'fest presswe t�nks al
muteriul, �ioor wo�kmnnship,or failure lo cuuy�ly with��pproving�ulhorilY�y nurnu�l waler level and ulr pressure nnd mesistnc plf �ttCSSUrC tl�O�l, whlch
requiremenls or lucnl u�din�nces. All "Nu" unswers sl�t�ll be explained 'In shnll nol exeeed 1.5 psi(0.1 bars)in 24 hrs.
lhe Conmicnls poiliui of Ihis linm. I
I'm�cil N�inc; � a.� O. 'Tesls
I Y ___I---�Se._�:��_ �� �-►•�r' 1
t'ro��eily nd�lress: NQ '�nb �Jc� ( I. t111 piping hydrosl:►lically leslecl al 00 ��si for o� hours
U�ilc;:_ 8
lt. 1'Inns �'i�1zy �t`�( ,� 2. I)ry piping �ineumalic�illy Icslccl U Yes U No
I. Acce�ile�l by /��i��roving Aulhuiilics (Names): � 3. f:yui�mienl o�ierales pro�,erlY C] Yes U No
�.. �
2. Address: �-- 4. Uo you ce�lify as tl,�e sprinkler conlrs�ctor lhat
3. InslaUution conli�n»s lo �cce��leil �rl�ins I1�Yes U Nu �Jililives and cc�rrosive cliemicals, soditmi
4 I�n,�!�=��„e,•� i�sed .'+� ;�, ,�uv�c! ! ! , silicale or ilerivalives of sodiwn siliciile, brine,
i I `'���y '-� 1'+'� or olher corrosive cheinicals �vere nc�l used fiir
C. Inslru�lions
I. I las persoi� in charge of iire equi��iiicnl bcen tesling syslems or slopping lesiks'l ❑ Yes O No
instrucled as lo Ic�c.iliun of conlrul val� 5. Uroin 7�esl;
es and
care �n�l ivainlen;ince of this new ec�u �mient li�Yes O No ;�. Stalic pressure reading of gage localed ne.�r
2. I lave copies uf Ihe fi�llowiiig been Ieli oii Ilic�iremises: water sup�,ly connection �psi.
a. Syslem com�ionenls inslnicl�ns b. Ites'tdual press�re tvill► valve in lesl connection
L-��/Yes U No o��en wi�le��si.
b. (;are ancl m<iinlenance insliuclions lJ Yes Cl No
c. NI:PA '�5 6. Undergiound in;►ins iind le�d in conncclions lo
C`�Yes 11 No risers (luslied befure conneclian made ta sprinkler
U. Locufl�►n of syslem - Sii��plics buil�liiig:
l:. Sliri��lclers i piping end verified by copy of fonn Nu. 13-U ❑ Yes O No
Make Mo�lel Ycar M<ule Orilice I u,uilil Tcinperaturc �. �lushed by inslaller of underground piping O Yes �]No
�-P ��_ � �� � „i �r��� 8. If��owder driven lasleners nre used in concrele,
--��---- � � -1-�--�L____ has re�nescnlalive sam��le Iesting been
���.1 � ��� _1�-- -1�. �_ � ss A
_ _-� salisf�clorily com��leled'l O Yes ❑No
1'. lilnnit 7'cslln6 Gaslccls
- --- ---- - I. Number useeL• 'r-
I�. Pipc uud I�illings f� 2. Localions: �--'-
I."Ty��e�;�f 1'ipe:_ ("� 'V�� 3. Nuuiber remove�l: ---� --
2. T�y��� �,r r�u�„65:�z� I'�FI�� _ �2. Weldcd 1'ipinb- If weldecl pi�iing w�s use�l in lhe syslem,
G. Alnrm Vnlve or I�low lndicnlur �omplelc Ihe following:
�_���----r--• I. !)�� y�ii� cerlify ;�c il,� spcii�k!er e��szL•acla� ll:�!
i� �C Mt1KC Nlo�lel Max, -Time lo .)per�le Throu61► lnsp. 1�esl '
Vp,r�� �� ��_ - wclding procedures com��ly with the require-
menls of al les�sl �1WS U10.9, Level AR-3 l�Yes U No
1. I)ry-Pipc Vulvc 2. ��o you ceilify Ih�l the wel�ling w�s perli�nned
. Make and Model: � by wel�lers qualifie<I in com��li;�nce wilh 11►e re- �1
2. 'eri;il Number: __ - quirements of�l leasl AWS D10.9, Level �1R-3 lrJ Ycs ❑No
1. (1u �Ie Opening 1)evicu (Q.O.I>.) � 3. Do you ceilify that welding was carried uul in
I. Mu ' flllO MO(ICI; complinnce wilh a documenled quality control
?. Scrial umber, procedure lo insure that s�ll discs are retiieved,
J. Ihy-1'i�►c 'yslem Uperaling '1'esl 1�illiuul (1.O.U. orenings in lhe �ipe are smooll�, sl;►g and olher
I. "l�ime lo t ' � Ihrough lest coniieclioii''• wel�ling residue are removc�l, and lhe Inlernal
?. Waler press re _ psi. �1ir pressure i ��Si. �liamelers of pi��ing are nol ��enelraled f➢�Yes O No
3. "I'rip�iuinl air iressure_--- ��si; R. Culouls(Ulslcs)
4. Time �vater rea �eil lesl uullcl•: I)o you ce�lify lhal you h;ive a control (enlure lo
5. Alarm o�ierale�l � uperly C1 1'es �j N�� ei�sure Ihal all culouls (�lisks) are relrieved'l �Ycs ❑No
IC. Ury-1'ipc Systcu� ( icruling '1'cst Wilh .O.U. �5. Ily�lruulic Unln N��mcplalc 1'rovidcd L�Yes l] No
I. Tiine tu Iri�� Ihrough esl conneclion'': �1'. Uule Icft in servlce (will► all contrul valves open):
?. Waler ��ressure psi. ilir p ssurc ��si. - ll. Sig�uilures
3. �lip ��oinl .�ir ��ressure _ ��s', I. Name of s�irinkler contiacleir: Ut �ri tiv�Id�
4. "Time �,v��ler reached lesl oi lel': 2. 7�ests�vilnessecl by: ;
S. Alann o��cr.�led ��roperlY Cl Ycs 11 iJo I��ir prope�ty owner (Sig�iecl): ___��'���
i,. i)ciugc un�i i'rc�►ction Vulvcs �l�i!!e: �r,l. , Uale:9�'�:SS
I. Makc an�l Mucicl: for sprinkler cunlraclor (Si6ned • -�;--
2. O�>eralion: ❑ 1'ncumatic^ filccli • �J Ily�lrawlic ---- Tille: �e�^ti.,--e�---- _ Ualc:�.�9�
7. Piping and deleclin � m dia su�ervis d V. �-�����������ts ("Ihis section is li�r a�ldilional ex��I.in;Hion antl noles.
6 I Ll Ycs �l No nll "Nu" ;inswers n�usl be ex��l;iincd liere.)
4. f)oes valve o��er;►le I� m �nanu��l l�ip e il/ur
remole conlrol slati u Cl Yes ❑ No - ---
5. Is Iherc .in �cccssi Ic (acilily i�i cacli ciic►i' -
Ihr lesling U Yes C] No
G, Uoes eacli cir iit o�icrale su�iervision loss ala ii Cl Yes ❑No
7. Uoes e�ch c' cuil ci��er.�le valve rele;�se U Yes U Nu
K. Mf�xinuun une lo o�icr.ile �clease:---
M. Pressurc eQ�icing Vulvc _ __ _
1. Loc;�ti i nn�l [�luur:_ �
2. M�ik an�l Mt�dcl:
3. Se �ng; � -
4. ' alic Pressure: I��lel -- lui, OIullcl psi
5 tesidual Pressuie(l�luwing): Inlel-L� ��si, Uuticl si -
�. f�low ltale: 61���� _
ine�sured from lime i�is��ecl�►rs lesl connection is o�iened �-) ('heck hero if commenls cunlin�ie on reverse sicle of Ihis lonn
�i1�i�1:,i�,,,,-, „-��t-r.r.-.-�-.--.-;.--�-.;-�-r-- .-_---------.._ - ------ ------
Ji4J?'1rr ��/ /V6 w.i G�c',/
/ 7 So �a��s� .�
.�'�%//�.....�� ,�1�,�,
S.�o y L
� �,_ _ F�..
� '� � 3 � 00
/
CITY OF FRIDLEY ', �,,,�(�`��(��M; �IR� C.:C�D�
FIRE DEPARTMENT
6431 University Avenue NE
PERM[T
Fridley, Minnesota 55432 ; ;; i
(612)572-3611 Re+�e�p# Nr� `"'� ' P�rmit No ` '
(fax)571-1287
;: . ..::.:. .:.;.:::::>
Expires '
JOB ADDRESS:
NAME OF BUSINESS:
DESCRIPTION OF WORK TO BE DONE (check on reverse side for stipulations & fees):
ERC ID # (Hazardous Materials; if COST EVALUATION OF JOB
applicable): (for sprinkler permits only) $
PERMIT FEE: DATE WORK SCHEDULED:
OWNER: OWNER ADDRESS:
OWNER PHONE (Slreet)
(City,State,Zip Code)
CONTRACTOR: ADDRESS:
STATE LICENSE #:
(S tre e t)
PHONE #
(City,State,Zip Code)
This permit is granted subject to compliance with applicable codes, ordinances and
regulations governing the above described operations. This permit is non-assignable and
shall be maintained in the place of business for which the permit is granted.
Date Authorized by: Richard H. Larson,
Deputy Chief/Fire Marshal
V I K I N G LETTER OF TRANSMITTAL
AUTOMATIC SPRINKLER COMPANY � 2400 ROSE PLACE nTE --�( JOB NO. �� � �
ST. PAUL,MINNESOTA 55113 �1�,t,l � �,
(612)636-4680 ATTENTION
FAX: (612) 636-4685 ��L hCA,r �G1;�('S'�Y�
FIRE PROTECTION RE:
p��,l'(�S k E��5 P��s-� �������.
TO
� � �y O�F I-r;d�� .�
C��i 3l un�v��-��., �1�� N�
�r�c�ttv ���; � 5SN 3�-
GENTLEMEN:
• WE ARE SENDING YOU......... ❑ Attached ....... ❑ Under separate cover via the following items: —
❑Shop drawings ❑ Prints �lans ❑Samples ❑Specifications
❑Copy of letter ❑Change order fa CCi.�C�.�0.�o an S
COPIES DATE NO. DESCRIPTION
s � � n F ��,.�S o� �r�.. �-e.c-���. �
� �1,,� 4/ 8 t �G t Cc�,l �,��5
�3 � �(/ � ��►� i Ne�:d -s .
� r� � a �= �-,�. I- h -� ,.�
THESE ARE TRANSMITTED as checked below:
6�For approval ❑ Approved as submitted ❑ Resubmit copies for approval
�For your use ❑ Approved as noted ❑ Submit copies for distribution
�As requested O Returned for corrections Cvf Return �_corrected prints _
. Q'For review and comment ❑
O FOR BIDS DUE 19 PRINTS RETURNED AFTER LOAN TO US
REMARKS:
�
COPY TO
SIGNED:
IF ENCLOSURES ARE NOT AS NOTED,KINDLY NOTIFY U AT ONCE:
� . , � . .
-
� �•� � �.- i.
/��
Quick Response R�s�,�
}
U ri ht Pendent Recessed Pendent, �
p g , ,
Sidewall & Recessed Sidewall ����
Glass Bulb Automatic Sprinklers �`
Manufactured by: Central Sprinkler Company
451 North Cannon Avenue. Lansdale. Pennsvlvania 19446
P ro d u ct Sprinklers are available with two sTandard
finishes, brass or chrome plated and with ����
two coatings, black or white, with additional �i �
�es�r�pt i o n special painted finishes available upon I
request.
The Central Ivledel GB-�R Automatic The Model GB-QR Pendent is Listed as
Sprinklers embrace the ultimate in recessed quick resoonse with Factory
Mutual when usinc a special recessed `
advanced design reatures. They escutcheon. Make sure to order the correct " �
incorporate the latest in glass bulb recessed escutcheon when Factory Mutual
technology, which result in a much smalier, approval is required. The part numbers are
more attractive sprinkler. The operating 3071 for chrome , 3072 for bright brass.
mechanism consists of a liquid-filled 3 mm 3070 brushed brass. 3075 off white, 3073 �
diameter frangibie capsule that is only 2.0 White, 3074 black. This escutcheon is not
cm in 'ength. ��
The Model GB-QR Automatic Sprinklers needed to maintain a quick response Listing �
are intended for installation in accordance at U.L. ,F
with current NFPA Standards. They are Operation: The glass bulb capsule '�
operating mechanism contains a heat- R.�#
a�iailable in 1/2" and 7/16" orifice sizes and sensitive liquid that expands upon �r'
155°F, 175°F, 200°F and 250°F application of heat. Upon reaching the
temperature ratings. The Model GB-(�R rated temperature, the franqiCie capsule � r r
�
�'e c�n i ea i ruptures thereby releasing the orifice seaL
The sprinkler then discharges water in a
pre-designed spray pattern to control or
Data extingui��n the fire.
Standard Applications i
The Model GB-QR Automatic Sprinklers are intended for standard area cover- ��, *�'
ages, and flow and pressure requirements as specified in current NFPA Stan- p -�
dards for Quick Response Automatic Sprinklers. r'
Model& �ii Orifice � I� � Thread �k��'
Deflector ', and Temperature i Approved ' Standard ' ; Size �''`��"'"'
Style '� K-Factor � Rating � Escutcheon '� Finishest ; Approvalsl (NPT) � �,;
GB-QR 1/2",5.6 155°F/68°C N/A Brass �� U.L. � 1/2" �;
Uqright 7/16".4.5 175°F/79°C Chrome Plated U.L.C. I
j 200°F!93°C i, F.M.'* i,
� 250°F/121°C I ! ' �
� i , �
GB-QR � 1i2",5•6 155°F/68°C Model I Brass ��� U.L. 1/2"
Pendent 7!�6".4.5 175°F.r19°C GB-Res.iQR ChromePlated �� U.LC. 1 /2„ & 7/16"
200°Fi93°C `Recessed I F.M.'*
250°F/121°C ' I
' ;� ' ' ' ' Orifice
GB-QR 1i2",5.0 �, 155°Fi68°C � Model ; Brass �I U.L. ;� 1/2"
Sidewall ', 175°F!79°C � GB-Res.iQR � Chrome Plated ; U.L.C. ,
�I 200°F,%93°C ! Recessed i , F.M."*'` ���0���'�
250°Fi121°C I ' �
t �Nhite.blacic and off-whife available�pon request.
• ;vlaximumworkingpressure: 175p.s.i. Sprinkler
• FactoryHydro Test: 100°0 �SOOp.s.i.
' Recessed Pendentis U.L.Listed for 155'F%68°C onlv.
'`*F.M.Approval is for 1i2"on/y and does not inc/ude painted versions.
Recessed versions must use a specia/recessea escutcheon.
"'`,�.M.Approval forthe Sidewall Sprinkleris not fo�Recessed. No. 3-10.0
, Figure 1 - Model GB-�R Recessed Pendent
�
, �
� �
� �
, � _
*SUPPORT CUP I I i�
I �
GB Res./�R RECESSED � I
ESCUTCHEON. � �--- ___� FACEOFREDUCING
COUPLING I
I
3/4"MAX. i
� 3/8" MIN. i
� � � �
I � IiI
� I FINISHED 2„
�--� CEILMG �
1 3/8" LINE
MAX. �
I � i I
1„ I �
MIN.
I I
I I I
I � , , . . :� . . . .
!__...L__ i _ __.. . __. _ .— ___.. t
�----1 13/16" I
2 7/8" i
`Support cup with FM Approval has slots in the face,the standard U.L.version does not.
Figure 2 - Model GB-�R Pendent Figure 3 - Model GB-�R Upright
� ;
� �
', ; , sis° -
� �
( - -�-
} --- —__
FACE OF i i i I
REDUCING � �
i i
COUPLING i i
- � �--- ---� �
�
i �i
' i
1'
�� I
2��
1 11/16"Ref. � 2„
I I
I —'---'-�
� -
i
J ��-
� � I I� �
'� � i
. ' �
� , .
t_ -- ___. --�
------ --
�--1 3/16" ' __
Note: Central's Model 65 or 401 escutcheon may be used. When
using Central's Model 65 escutcheon,face of R.C.to protrude
�/g��±1/16"beyond finished wall line.
2
. � Figure 4 - Model GB-QR Recessed Sidewall Design
FACE OF ,
REDUCING . 3/4"MAX. � FINISHED Data
COUPLINC 3/8"MIN. WALL LINE
—_-_._ �------ . . _. .. _
f
, ' � The Model GB-QR Automatic Sprin-
S�PPoAT��P ; klers are intended for standard area
\ �, coverages and flow and pressure re-
�. � - � � - i quirements as specified in current NFPA
yj� , ' Standards for quick response sprinklers.
` i �__-,
I i
� .
_ ;, � ; 27;8�� Installation
I1 13/16"
�.,. . .,... .,...l_.. �y� .
; � � All Central Model GB-QR Automatic
` i '�' � Sprinklers must be installed according to
, i current NFPA Standards. Deviations from
� �' - - - - ; t h e s e r e q u i r e m e n t s a n d s t a n d a r d s o r a n y
alteration to the sprinkler itself will void
GB Res.;oR RECESSED � 'I any warranty made by Central Sprinkler
ESCUTCHEON � I
I, �� � Company. In addition, instailation must
!' � also meet locai government provisions,
--- - --_ _ t
_3/8'Adjustment. � �- codes, and standards as applicable.
Range
The system piping must be properly
sized to ensure the minimum required flow
rate at the sprinkler.
Check for the proper model, style, orifice
size, and temperature rating prior to
Figure 5 - Model GB-QR S'tdewall installation. Install sprinklers after the
' piping is in place to avoid mechanical
damage; replace any damaged units.
Wet pipe systems must be protected from
`��----;
� freezing.
� Upon completion of the installation, the
- P �i system must be tested per recognized
' standards.
��� In the event of a thread leak, remove the
� unit, apply new pipe joint compound or
� tape, and reinstall.
� Installation Sequence
.r� '
.-'
� �----�
.- - z siis° -
Note: Use the Combination Wrench
For Upright Sprinklers and the GB
Note: Central's Model 65 or 401 escutcheon may be used. When using Central's Model 65 S rinkler Wrench For Pendent and
escutcheon,face of R.C.to protrude 1/8"±1/16"beyond finished wall line. p
Sidewall Sprinklers.
Step 1. The unit must be installed in the
Combination Wrench (Part#1106) GB Sprinkler Wrench (Part #1099) upright position for the upright style
(For Upright Sprinklers) (For Pendent & Sidewall Sprinklers) sprinklers or in the pendent position for
pendent sprinklers, and in the sidewall
position for sidewall sprinklers.
Step 2. Use only a non-hardening pipe
�- �� I joint compound or Teflon* tape. Apply
onty to male threads.
Step 3. Install the sprinkler according to
the dimensions shown in the installation
�� � � � �� diagrams on pages two and three of this
,
technical bulletin. For recessed
_ .. ...w:� ��....�,.�..,, „ . .�. , .. .: . , W;
3 'Teflon is a trademark of the DuPont Corp.
applications, do not use the push-on The NFPA standard 25 entitled, Drain water and relieve pressure in the
escutcheon plate to hold the unit in "Inspection, Testing and Maintenance pipes. Remove the existing unit and
position. The sprinkler will only of Water-Based Fire Protection install the replacement, using only the
function properly when anchored to the Systems", contains guidelines and recommended sprinkler wrench. Be
building structure. minimum maintenance requirements. certain to match model, style, orifice,
Step 4. Hand tighten the sprinkler into Furthermore, the local Authority Having and temperature rating.
the fitting. Then use a Central Jurisdiction may have additional A fire protection system that has been
Universal Wrench for pendent regulations and requirements for shut off after an activation should be
sprinklers, and a Central Combination maintenance, testing, and inspection returned to service immediately. Inspeci
Wrench for upright and sidewall that must be obeyed. the entire system for damage and
sprinkiers, to tighten the unit into the It is recommended that sprinkler replace or repair as necessary.
fitting. A leak-tight joint requires only 7 systems be inspected regularly by a Sprinklers that did not operate but were
to 14 ft.-Ibs. of torque; a tangential qualified inspection service. Length of subjected to corrosive elements of
force of 14 to 28 Ibs. delivered through time between such inspections can combustion or excessive temperatures
a 6" handle will deliver adequate vary due to accessibility, ambient should be inspected, and replaced if
torque. Torque levels over 21 ft.-Ibs. atmosphere, water supply, and site need be. The Authority Having
may distort the orifice seal, resulting in activity. Jurisdiction will detail minimum
leakage. Do not attempt to reassemble or replacement requirements and
Caution: Special care must be otherwise reuse a sprinkler that has regulations.
taken when installing sprinkiers with a operated. Replace any sprinkler Guarantee: Central Sprinkler
CPVC system. Sprinklers must be exhibiting corrosion or damage; always Company will repair and/or replace any
installed after the manufacturer's use new sprinklers of the same type products found to be defective in
recommended setting time for the and temperature rating as material or workmanship within a period
primer and cement to ensure that replacements. of one year from the date of shipment.
neither accumulate within the sprinkler. Because the discharge pattern is Please refer to the current Price List for
Special care must be taken when critical to protection of life and further details of the warranty.
installing with a copper system. property, nothing should be hung or •
Sprinklers must be installed only after attached to the sprinkler unit that would Ordering
the inside of the sprinkler drop and disrupt the pattern. Such obstructions .
associated fittings have been wire must be removed. In the event that Information :� -��
brushed to remove any flux. Residual construction has altered the original
flux can cause corrosion and in configuration, additional sprinklers may Ordering Information: When
extreme cases can impair proper need to be installed to maintain the placing an order, indicate the full
sprinkler operation. protection level. product name. Please specify the
Do not attempt to replace sprinklers quantity, model, style, orifice size,
without first removing the fire temperature rating, type of finish or
Care & protection system from service. Be coating, and sprinkler wrench.
certain to secure permission from all Availability and Service: Central
���� Authorities Having Jurisdiction, and sprinklers, valves, accessories, and
notify all personnel who may be other products are available through-
affected during system shutdown. A out the U.S. and Canada, and
Sprinklers must be handled carefully. fire watch during maintenance periods internationally, through a network of
They must not be transported or stored is a recommended precaution. Central Sprinkler distribution centers.
where ambient temperature may To remove the system from service You may write directly to Central
exceed 100°F/38°C. For best results, mode, first refer to your system Sprinkler Company, or call 215-362-
store them in a cool, dry location in the o eratin uide and valve instructions.
original shipping package. p g g 0700 for the distributor nearest you.
Do not install sprinklers that have Patents: Patents are pending.
been dropped or visibly damaged. Conversion Table:
Sprinklers must never be painted, 1 inch = 25.400 mm
coated, plated, or altered in any other 1 foot = 0.3048 M
way from manufactured condition or 1 pound = 0.4536 kg
they may not function properly. Any 1 foot pound = 1.36 Nm
sprinklers altered in such manner must C�NTRAL 1 psi = 6.895 kpa
be replaced. = 0.0689 bar Z
The owner is responsible for the �� = 0.0703 kg/cm 3
proper operating condition of all fire 1 U.S. gallon = 3.785 dm
protection devices and accessories. Centt'81 SPt'111k1e1' COtllpatly = 3.785 liters
451 N. Cannon Avenue, Lansdale, PA 19446 Conversions are approximate.
OO 1996 Central Sprinkler Company Phone (215) 362-0700 GB-QR.4
Printed in U.S.A. FAX (215) 362-5385
��
"`--`
f � �
�
- - - - F i�-� F•�-•=•t� = t 1•_• �-� 1�- a - _•��� ��•�_�t��- C• � _-i•��i -�
Viking Automatic Sprinkler Co.
1301 L'Orient Street
St Pau1 MN 55i17
612-558-3300
Job Name : PLUNKETTS PEST CONTROL
Building .
Location : 40 52ND WAY
System : REMOTE #1
Contract : 128084
Data File : 128084a.WX1
Computer Programs by Hydratec Inc. Route 111 Windham N.H. USA 03087
Viking Automatic Sprinkler Co. Page 1
PLUNKETTS PEST CONTROL Date 080298
Hydraulic Design Information Sheet
Name - PLUNKETT PEST CONTROL Date - 071798
Location - 40 52ND WAY
Building - System No. - REMOTE #1
Contractor - VIKING AUTOMATIC SPRINKLER C0. Con�ract No. - 128084
Calculated By - AARON HUNTER Drawing No. - 1 OF 1
Construction: ( ) Combustible (X) Non-Combustible Ceiling Height - VARIES
Occupancy - OFFICE
S (X) NFPA 13 (X) Lt. Haz. Ord.Haz.Gp. ( ) 1 ( ) 2 ( ) 3 ( ) Ex.Haz.
Y ( ) NFPA 231 ( ) NFPA 231C (X) Figure 5-2 .3 Curve 3
S Other
T Specific Ruling Made By Date
E
M Area of Sprinkler Operation - 900 System Type Sprinkler/Nozzle
Density - 0.1 (X) Wet Make CENT?2AL
D Area Per Sprinkler - 210 ( ) Dry Model GB QR
E Elevation at Highest Outlet - 16. 125 ( ) Deluge Size 1/2"
S Hose Allowance - Inside - ( ) Preaction K-Factor 5. 6
Z Rack Sprinkler Aliowance - ( ) Other Temp.Rat.155
G Hose Allowance - Outside - 100
N
Note
Calculation Flow Required - 188.05 Press Reauired - 59.013 At UND
Summary C-Factor Used: 120 Overhead 140 Underground
W Water Flow Test: Pump Data: Tank or Reservoir:
A Date of Test - JULY 21/98 Cap. -
T Time of Test - 10: 15 AM Rated Cap.- Elev.-
E Static Press - 74 @ Press -
R Residual Press - 54 Elev. - 1.0 Well
Flow - 2988 Proof Flow
S Elevation - 1.0
U
P Location - 40 52ND WAY
P
L Source of Information - FLOW TEST BY VIKING AND CITY OF FRIDLEY
Y
C Commodity Class Location
0 Storage Ht. Area Aisle W.
M Storage Method: Solid Piled � Palletized o Rack
M
( ) Single Row ( ) Conven. Pallet ( ) Auto. Storage ( ) Encap.
S R ( ) Double Row ( ) Slave Pa11et ( ) So1id She1f ( ) Non
T A ( ) Mult. Row ( ) Open Shel�
0 C
R K F1ue Spacing Clearance:Storage to Ceiling
A Longitudinal Transverse
G
E Horizontal Barriers Provided:
Computer Programs by Hydratec Inc. Route 111 Windham N.H. USA 03087
Viking Automatic Sprinkler Co. Page 2
PI�UNKETTS PEST CONTROL Date 080298
City Water Sup�>ly: Pump Data:
C1-Static Pressure: 66 PSI
C2-Residual Pressure: 48 PSI
C2-Residual Flow: 2568 GPM
150
D1-Elevation: 3.898 PSI
140 D2-System Flow:288.05 GPM
D2-System Pressure: 59.535 PSI
130 Hose ( Adj City ) :0 GPM
Hose ( Demand ) :0 GPM
D3-Total Flow:288.05 GPM
P 120 Safety Margin: 6. 151 PSI
R 110
E 100
S 90
S 80
� 70
R 60
E 50 C2
40
30
20
10
1
300 600 900 1200 1500 1800 2100 2400 2700
FLOW ( N ^ 1.85 )
Coinputer Programs t�y Hydratec Inc. Route 111 Windham N.H. USA 03087
Viking Automatic Sprinkler Co. Page 3
PL'JNKETTS PEST CONTROL Date 080298
Fitting Legend
Abbrev. Name
A Alarm Valve
B Buttertly Valve
C Ro11 Groove Coupling
D Dry Pipe Valve
E 90' Standard Elbow
F 45' Elbow
G Gate Valve
K Detector Check Valve
L Long Turn Elbow
M Medium Turn Elbow
N POZ-LOK 90 ELL
0 POZ-LOK TEE
Q Flow Control Valve
S Swing Check Valve
T 90 ' Flow thru Tee
W Wafer Check Valve
Z Flow Switch
Computer Programs by Hydratec Inc. Route 111 Windham N.H. USA 03087
Viking Automatic Sprinkler Co. Page 4
PLUNKETTS P�ST CONTROL Date 080298
Unadjusted Fittings Table
1/2 3/4 1 1/4 1 1/2 2 2 1/2 3 3 1/2 4
A 7.7 Z1.5 17.0
B 7 lO 1L
C 1 1 1 1 1 1 1 1 1 1
D 9.5 17 28
.. 2 2 2 3 4 5 6 7 8 10
F 1 1 1 1 2 2 3 3 3 9
G 1 1 1 1 2
iC 14 14
L 1 1 2 2 2 3 4 S 5 6
M 2 2 3 3 4 5 6 0' 8
N 2 3 16
0 5 7 31
Q 16 29 35
S 4 5 5 7 9 11 14 16 19 22
T 3 4 5 6 8 10 12 15 17 20
W 10.3
Z 2 2 2 3 4 5 6 7 8 10
5 6 8 10 12 14 16 18 20 24
A 17 27 29
B 9 10 12 19 21
C 1 1 1 1 1 1 1 1 1 1
D 47
E 12 14 16 22 27 35 40 45 50 61
. 5 7 9 11 13 17 19 21 24 28
G 2 3 4 5 6 7 8 10 11 13
K 36 55 45
L 8 9 13 16 18 24 27 30 34 40
M 10 12 16 19 22
N
0
Q 33
S 27 32 45 55 65 76 87 98 109 130
T ZS 30 35 50 60 71 81 91 101 121
w 13.1 31.8 35.8 27.4
Z 12 14 18 22 27 35 40 45 50 61
Computer Programs by Hydratec Inc. Route 111 Windham N.H. USA 03087
Vikinq Automatic Sprinkler Co. Page 5
PLJNKETTS PEST CONTROL Date 080298
Node Elevation K-Fact Press Flow Density Area Press
No. Actual Added Req. Req.
D001 6 5.6 14.06 21 .1000 210.00 7.000
D004 8 5.5 7 14.62 .1000 148 7.000
10 10 K = K@ EQO1 15.55 21
11 10 K = K@ EQO1 17.22 22.1
12 10 K = K@ EQ01 21.09 24.8
13 10 K = K@ EQO1 24.26 26.23
14 I5.792 28.95
1 9.33 K = K@ SQ04 15.34 20.8
2 9.33 K = K@ EQ09 16.65 21.67
3 9.33 K = K@ EQ04 21.96 24.89
4 9.33 K = K@ EQ04 25 26.56
5 15.792 27.�1
6 15.792 31.96
7 15.792 35.18
8 15.792 44.64
9 15.792 97.86
56 15 48.63
TASR 15 52.28
VA S 56.89
UND 1 59.01
TEST 1 59.53 100
The masimum velocity is 26.99 and it occures in the pipe between nodes 6 and 7
Computer Programs by Hydratec Inc. Route 111 Windham N.H. USA 03087
Viking Automatic Sprinkler Co. Page 6
PLUNK�TTS PEST CONTROL Date 080298
Hyd. Qa Dia. Fitting Pipe Pt Pt
Ref. "C" Or FtZg'S Fe Pv ******* NOt25 ******
Point Qt Pf!UL Eav. Ln. Tota1 Pf Pn
D001 21.00 1. 104 1T 6.413 7.000 14 .063 14 .063 K cactor = 5. 6
to 120 6.413
EQOl 21.00 0.1110 13. 413 1 . 489 �Iel = 7.038
21 .00 15.552 K Factor = 5.33
D004 14 .82 1. 104 1T 6.413 7.000 7.000 7 .000 K Factor' = 5. 6
to 120 6.413
EQ04 14 .82 0.0583 13.413 0.782 Vel = 4 . 967
14 .82 7 .782 K Factor = 5.31
10 21.00 1. 104 15.000 15.552 15.552 K Factor @ node EQO1
to 120
1� 21.00 0.1111 15.000 1. 6'06 Ve1 = 7.038
1' 22.10 1 . 104 i0. 660 17.218 i7 .218 K Factor @ node EQO1
to 120
12 43.10 0.4199 10. 660 4 .476 Vel = 14 .445
12 24.80 1 .452 10.000 21. 693 21. 693 K Factor @ node EQ01
to 120
13 67. 90 0.2564 10.000 2 .564 Vel = 13. 156
13 26.22 1. 687 lE 5.022 26.850 24 .257 24 .257 K Factor @ node EQO1
to 120 5.022 -2.509
19 94. 12 0.2259 31.872 7 .200 Vei = 13.510
14 1 . 687 1T 10.044 3.290 28 . 949 28. 949
to 120 10.044
6 94.12 0.2259 13.334 3.012 Vel = 13.510
94 . 12 31. 961 K ractor = 10. 55
1 20.80 1.104 12 .000 15.341 15.341 K Factor @ node EQ04
to 120
2 20.80 0. 1091 12.000 1.309 Vel = 6. 971
2 2i. 68 1.104 13.000 16. 651 16. 651 K �actor @ node PQ04
to 120
3 42.48 0. 4088 13.000 5.315 Vel = 14 .238
3 24.89 1.452 12.000 21. 965 21. 965 K Factor @ node EQ04
to 120
4 67.3? 0.2527 12.000 3.032 Vel = 13.053
4 26.55 1. 687 23.170 24 . 996 24 . 996 K Factor @ node EQ04
to 120 -2.799
5 93. 92 0.2250 23.170 5.214 Vel = 13.481
5 1. 687 1E 5.022 5.150 27.412 27 .412
to 120 1T 10.04� 15.066
6 93. 92 0.2250 20.216 4 .549 Vel = 13.481
6 94 .13 1. 687 3. 960 31 . 961 31. 961
to 120
7 188.05 0.8129 3. 960 3.219 Ve1 = 26. 992
7 2 . 154 1T 12.22� 26.030 35.180 35. 180
to 120 12.224
8 188.05 0.2473 38.254 9.459 Ve1 = 16.557
Computer Programs by Hydratec Inc. Route 111 Windham N.H. USA 03087
Viking Automatic Sprinkler Co. °age 7
PLUNKETTS PEST CONTROL Date 080298
Hyd. Qa Dia. Fitting Pipe Pt Pt
Ref. "C" or Ftng's Pe Pv ******* Notes ******
Pcint Qt Pf/UL Eav. Ln. Total Pf Pn
3 2.154 1T 12.224 0.790 44 . 638 44 . 638
to 120 12.22�
9 188.05 0.24i3 13.014 3.218 Ve1 = 16.557
9 3.356 15.000 47.856 47 .856
to 120 0.343
56 188.05 0.0285 15.000 0. 428 Vel = 6.821
56 3.356 2E 10.836 106.360 48. 627 48 . 627
to 120 21.672
TaSR 188.05 0.0285 128 .032 3. 653 Ve1 = 6.821
T�SR 3.356 9.792 52.280 52 .280
to 120 4 .331
V� 188.05 0.0285 9.792 0.279 vel = 6.821
VA 4 .026 1B 12.000 5.208 56.890 56.890
to i20 1G 2.000 28.000 1.732
WiD 188 .05 0 .01i? l� 14 .000 33.208 0.390 Ve1 = 4 .739
UND 6. 16 468.000 59.013 59.013
to 140
T�ST 188 .05 0.0011 468.000 0.52i Vel = 2.024
100.00 Qa = 100.00
288.05 59.534 K Factor = 37.33
Computer Programs by Hydratec Inc. Route 111 Windham N.H. USA 03087
> 6l �/ /r�� z�
Z ri S�7
/��/ c.� �j �c
,
_�--
�� �
� - �
- - . _ F i i-v- F•t-•=•t-� =t 1•_•�-� I�- a - -•��� ��•�_ it�i- C• � -_-i•_�� -i
Viking Automatic Sprinkler Co.
1301 L'Orient Street
St Paul MN 55i17
612-558-3300
Job Name : PLUNKETTS PEST CONTROL
Building .
Location : 40 52ND WAY
System : REMOTE #2
Contract : 128084
Data File : 128084B.WX3
Computer Programs by Hydratec Inc. Route 111 Windham N.H. USA 03087
Viking Automatic Sprinkler Co. Page 1
P��UNKET;S PEST CONTROL Date 080398
Hydraulic Design Information Sheet
Name - PLUNKETT PEST CONTROL Date - 071798
Location - 40 52ND WAY
Building - System No. - REMOTE #2
Cor.tractor - VIKING AUTOMATIC SPRINKLER C0. Contract No. - 128084
Calculated By - AARON HUNTER Drawing No. - 1 OF 1
Construction: ( ) Combustible (X) Non-Combustible Ceiling Height - VARIES
Occupancy - WAREHOUSE/ STORAGE
S (X) NFPA 13 � Lt. Haz. Ord.Haz.Gp. ( ) 1 (X) 2 ( ) 3 ( ) Ex.Haz.
Y ( ) NFPA 231 ( ) NFPA 231C (X) rigure 5-2 .3 Curve 3
S Other
T Soecific R�iling Made By Date
E
M Area of Sprinkler Operation - 1256 System Type Sprinkler/Nozzle
Density - 0.2 (X) Wet Make CENTRAL
D Area Per Sprinkler - 130 ( ) Dry Model GB QR
E Elevation at HighesL Outlet - 16.125 ( ) Deluge Size 1/2„
S Hose A1lowance - Inside - ( ) Preaction K-Factor 5. 6
I Rack Sprinkler Allowance - ( ) Other Temp.Rat.155
G Hose Allowance - Outside - 250
N
Note
Calculation Flow Required - 297.30 Press Required - 64 .8I8 At liND
Summary C-Factor Used: 120 Overhead 140 Underground
W Water Flow Test: Pump Data: Tank or Reservoir:
A Date of Test - JULY 2i/98 Cap. -
T Time of Test - 10:15 AM Rated Cap.- Elev.-
E Static Press - 74 @ Press -
R Residual Press - 54 Elev. - 1.0 Well
Flow - 2988 Proof Flow
S Elevation - 1.0
U
P Location - 40 52ND WAY
P
L Source of Information - FLOW TEST BY VIKING AND CITY OF FRIDLEY
Y
C Commodity Class Location
0 Storage Ht. Area Aisle W.
M Storage Method: So1id Piled % Palletized � Rack
M
( ) Single Row ( ) Conven. Pallet ( ) Auto. Storage ( ) Encap.
S R ( ) Double Row ( ) Siave Pa11et ( ) Solid She1f ( ) Non
T A ( ) Mult. Row ( ) Open She1f
O C
R K F1ue Spacing Clearance:Storage to Ceiling
A Longitudinal Transverse
G
E Horizontal Barriers Provided:
Computer Programs by Hydratec Inc. Route 111 Windham N.H. USA 03087
Viking Autumatic Sprii�kler Co. Page 2 "
PLUNKETTS PEST CONTROL Date 080398
City Water Supply: Pump Data:
C1-Static Pressure: 74 PSI
C2-Residual Pressure: 54 PSI
C2-Residual Flow: 2988 GPM
150
D1-Elevation: 6. 406 PSI
140 D2-System Flow:547 .3 GPM
D2-System Pressure: 66.035 PSI
Hose ( Adj City ) :0 GPM
130 Hose ( Demand ) :0 GPM
D3-Total Flow:597.3 GPM
P 120 Safety Margin: 7.099 PSI
R 110
E 100
S 90
S 80
1
� 70
R 60
C2
E 50
90
30
20
10 1
300 600 900 1200 1500 1800 2100 2900 2700
FLOW ( N ^ 1.85 )
Computer Programs by f�ydratec Inc. Route 111 Windham N.H. USA 03087
Viking Automatic Sprinkler Co. Page 3
nLUNKETTS" PEST CONTROL Ddte 080398
Fitting Legend
Abbrev. Name
A Alarm Valve
B Butterfly Valve
C Ro11 Groove Coupling
D Dry Pipe Valve
E 90 ' Standard Elbow
F 45' E1bow
G Gate Valve
K Detector Check Valve
L Long Turn Elbow
M Medium Turn Elbow
N POZ-LOK 90 ELL
O POZ-LOK TEE
Q F1ow Control Va1ve
S Swing Check Valve
T 90 ' Flow thru Tee
W Wafer Check Valve
Z F1ow Switch
Computer Programs by Hydratec Inc. Route 111 Windham N.H. USA 03087
Viking Automatic Sprinkler Co. Page 4
PLUNKETTS PEST CONTROL Date 080398
Unadjusted Fittings Table
1/2 3/4 1 1 1/4 1 1/2 2 2 1/Z 3 3 1/� 4
A 7.7 21.5 17.0
g 7 10 12
C 1 1 1 1 1 1 1 1 1 1
D 9.5 17 28
E 2 2 2 3 4 5 6 7 8 10
F 1 1 1 1 2 2 3 3 3 4
G 1 1 1 1 2
� 14 14
L 1 1 2 2 2 3 4 5 5 6
M 2 2 3 3 4 5 6 6 8
N 2 3 1'o
0 , 5 7 31
Q 18 29 35
S 4 5 5 7 9 11 14 16 19 22
T 3 4 5 6 8 10 12 15 17 20
W 10.3
Z 2 2 2 3 4 5 6 7 B 10
S 6 8 10 12 14 16 18 20 24
A 17 27 29
B 9 10 12 19 21
C 1 1 1 1 1 1 1 1 1 1
D 47
E 12 14 18 22 27 35 40 45 50 61
F 5 7 9 11 13 17 19 21 24 28
G 2 3 9 5 6 7 8 10 11 13
K 36 55 95
L 8 9 13 16 18 24 27 30 39 40
M 10 12 16 19 22
N
0
Q 33
S 27 32 45 55 65 76 87 98 109 130
T 25 30 35 50 60 71 81 91 101 121
W 13.1 31.8 35.8 27.4
Z 12 14 18 22 27 35 40 45 50 61
Computer Programs by Hydratec Inc. Route 111 Windham N.H. USA 03087
Viking Automatic Sprinkler Co. Page 5
FLUNKLTTS PEST CONTROL Da�e 080398
Node Elevation K-Fact Press Flow Density Area Press
No. Actual Added Req. Req.
57 15.792 5.6 21.So" 26 .2 130 7
58 15.792 5.6 22.98 26.84 .2 130 7
59 15.792 5.6 28.23 29.75 .2 130 7
60 15.792 5.6 31.22 31.29 .2 130 7
61 15.792 5.6 33.98 32.64 .2 130 7
62 15.792 35.25
8 15.792 38.32
9 15 40.7
50 16.125 5.6 22.87 26.78 .2 130 7
51 16.125 5.6 24.37 27.64 .2 130 7
52 16.125 5.6 29.92 30.63 .2 130 7
53 16.125 5.6 33.07 32.21 .2 130 7
54 16.125 5.6 35.82 33.51 .2 130 7
55 16.125 37.24
5o'A 10'.125 40.48
56 15 48.67
TASR 15 57.19
VA 5 62.17
UND 1 69.82
TEST 1 66.04 250
The maximum velocity is 26.18 and it occures in the pipe between nodes 56A and 56
Computer Programs by Hydratec Inc. Route 111 Windham N.H. USA 03087
Viking Automatic Sprinkler Co. Page 6
?L'JNK.ETTS PEST CONTROL Date 080398
Hyd. Qa Dia. ritting Pipe Pt Pt
Re�. "C" or Ftng's Pe Pv ******* Notes ******
Point Qt Pf/UL Eqv. Ln. Total Pf Pn
57 26.00 1. 104 8. 620 21.556 21.556 K Factor = 5. 6
to 120
58 26.00 0.1648 8. 620 1. 421 Vel = 8.714
58 26.84 1. 104 8.580 22. 977 22. 977 K Factor = 5. 6
to 120 •
59 52 .84 0. 6121 8 .580 5.252 Vel = 17 .710
59 29.76 1.452 8. 120 28 .230 28.230 K Factor = 5. 6
to 120
60 82 . 60 0.3683 8. 120 2. 991 Vel = 16.004
60 31.29 1. 687 8.580 31.221 31.221 K Factor = 5. 6
to 120
61 113.89 0.3214 8.580 2 .758 Vel = 16.347
61 32. 64 2.154 8. 160 33. 979 33. 979 K Factor = 5.6
to 120
62 146. 53 0.1559 8. i60 1 .272 Vel = 12.901
62 2. 154 1T 12.224 7.500 35.251 35.251
to 120 12.224
8 146.53 0.1559 19.724 3.074 Vel = 12.901
8 2. 154 1T 12.224 0.790 38 .325 38.325
to 120 12.224 0.343
9 146.53 0. 1558 13.014 2 .028 Vel = 12.901
9 3.356 15.000 40. 696 40. 696
to 120 -0.487
56A �46.53 0.0180 15.000 0.270 Vel = 5.315
146.53 40 .479 K Factor = 23.03
50 26.78 1.104 8 . 620 22.868 22.868 K Factor = 5.6
to 120
51 26.78 0.1741 8. 620 1.501 Ve1 = 8.976
51 27. 64 1.104 8.580 24 .369 24 .369 K Factor = 5.6
to 120
52 54 .42 0. 6465 8.580 5.547 Vel = 18.239
52 30. 63 1.452 8. 120 29. 916 29. 916 K Factor = 5. 6
to 120
53 85.05 0.3888 8 .120 3.157 Vel = 16.479
53 32.21 1.687 8.080 33.074 33.074 K Factor = 5. 6
to 120
54 117.26 0.3392 8.080 2 .741 Vel = 16.831
54 33.51 2.154 8. 660 35.815 35.8'�5 K Factor = 5. 6
to 120
55 150.77 0.1643 8. 660 1.423 Vel = 13.274
55 2.154 1T 12.224 7. 500 37 .238 37.238
to 120 12.224
55A 150.77 0.1643 19.724 3.241 Vel = 13.274
56A 146.53 2.154 1T 12.224 1.125 40.479 40.479
to 120 12.224 0.487
56 297.30 0.5770 13.349 7 .702 Vel = 26.175
Computer Programs by Hydratec Inc. Route 111 Windham N.H. USA 03087
Viking Automatic Sprinkler Co. Page 7
P�JiJK�T•TS PEST CONTROL Date 080398
Hyd. Qa Dia. Fitting Pipe Pt Pt
Ref. "C" or rtr.g's Pe Pv ******* Notes ******
Point Qt Pf/UL Eqv. Ln. Tota1 Pf Pn
56 3.356 2E 10.836 106.360 48. 668 48. 668
to 120 21. 672
TASR 297.30 0.0666 128.032 8.524 Vel = 10.783
TASR 3.356 9.792 57 .192 57.192
to 120 4 .331
VA 297.30 0.0666 9.792 0. 652 Ve1 = 10.783
VA 4 .026 1B 12.000 5.208 62. 175 62.175
to 120 1G 2.000 28 .000 1.732
UND 297.30 0.0274 1K 14 .000 33.208 0. 911 Vel = 7 .493
UND 6.16 468.000 64 .818 64 .818
to 140
TEST 297 .30 0.0026 468.000 1.217 Vel = 3.201
250.00 Qa = 250.00
547 .30 66.035 K Factor = 67.35
Computer Programs by Hydratec Inc. Route 111 Windham N.H. USA 03087